Cockle (Anadara granosa) meat wash water precipitate was hydrolyzed using bromelain. Experiments were carried out to determine optimum conditions for temperature, enzyme concentration and hydrolysis time using response surface methodology (RSM) based on a central composite rotatable design (CCRD) to obtain the highest value of nitrogen content (NC) and degree of hydrolysis (DH). Results revealed that the optimum conditions for temperature, enzyme concentration and hydrolysis time were 33.7°C, 1.45% (E/S) and 28.42 hrs, respectively. At the optimum condition, hydrolysis of cockle meat wash water precipitate using bromelain resulted in a NC of 0.6% and DH of 48%. The NC and DH were significantly influenced by temperature, enzyme concentration and hydrolysis time. When the bromelain concentration, hydrolysis time and temperature were increased, the values of NC and DH also increased. The hydrolysate produced contained flavor compounds found in clam and oyster which were 3-methylbutanol and 1-pentanol. The compound 3-MCPD was not found in the hydrolysate.
Dabai or Canarium odontophyllum Miq., from the family Burseraceae, is an important indigenous fruit to Borneo Island. However, it is a highly perishable fruit with short shelf life. Postharvest technology such as modified atmosphere packaging (MAP) can be used to maintain highly perishable fresh fruit quality and increase its shelf life. There is not much work has been carried out to study effect of MAP on dabai fruit. Therefore, this study was conducted to determine the effect of four different types packaging methods on the postharvest quality of dabai fruits. Total of 240 fruit were used for each replication and the experiment was repeated thrice. Fruit were divided equally into four groups with each group packed in low-density polyethylene plastic bag, low-density polyethylene plastic bags lined with tissue paper, low-density polyethylene plastic bag with vacuumed and control (unwrapped). The fruit were then stored in a cold room of 10°C for 8 days. The fruits were analyzed for peel and flesh colour (L*, C* and hue angle), CO2 and C2H4 production, weight loss, firmness, soluble solids concentration (SSC), titratable acidity (TA) and pH at every two days interval. Data were analyzed using analysis of variance and means was separated using Duncan’s multiple range tests. The use of MAP retained peel colour (L*, C* and hue angle values), flesh colour (L*values), SSC and TA of dabai fruit. The CO2 production in MAP fruit was significant lower than control. Although vacuum packed showed lowest weight loss, flesh discolouration, soggy texture and foul sour odour developed during 8 days of storage. Neither packing dabai fruit in low-density polyethylene plastic bag nor bag lined with tissue paper retained better fruit quality. Thus, it is recommended packing dabai fruit in low-density polyethylene plastic bag is sufficient to retain fruit quality during 8 days of storage at 10oC.
MeSH terms: Analysis of Variance; Atmosphere; Borneo; Color; Drug Packaging; Fruit; Odors; Vacuum; Weight Loss; Polyethylene; Burseraceae; Islands
Pepsin-solubilized collagen (PSC) was extracted from the body wall of crown-of-thorns starfish (COTS) (Acanthaster planci) using pepsin digestion in 0.5 M acetic acid. The electrophoretic pattern of PSC showed that it consisted of two α chains (α1 and α2 chains). In addition, the peptide mapping showed that there were some differences in peptide patterns among PSC, calf skin collagen and salmon skin collagen. This suggested that the primary structure of the PSC was different from calf skin collagen and salmon skin collagen. Furthermore, Fourier transform infrared spectroscopy (FTIR) investigation showed the existence of triple helical structure in PSC, suggesting that the triple helical structure was well preserved during the extraction of collagen from COTS. The denaturation temperature of PSC was 33.0°C, which was comparable with mammalian collagen. In addition, the amino acid composition analysis showed that the imino acid content of PSC was similar to mammalian collagen but it was higher than other marine collagen. This suggested that the imino acid content might contributed the denaturation temperature of collagen. The results in this study suggest that PSC from the underutilized COTS has potential to be exploited in various commercial applications.
Rice is a carbohydrate, one of the plant-based foods that can accumulate heavy metal from soil and the irrigation water. Since total heavy metal always overestimates the amount of heavy metal available in rice, bioavailability of heavy metal is always preferred. Many studies have been done and found that in vitro methods offer an appealing alternative to human and animal studies. They can be simple, rapid, low in cost and may provide insights which not achievable in the in vivo studies. In vitro digestion model for rice may differ from other in vitro digestion models applied in soil or other type of foods studies. This review aims to provide an overview of in vitro digestion model used to determine bioavailability of heavy metal in rice, summarize health risk assessment application of heavy metal in rice studies and highlight the importance of health risk assessment to be included in the studies. Future exploration of in vitro digestion model and health risk assessment application on the bioavailability of heavy metal in rice was also suggested.
Impacts and relationships on physicochemical properties in dark chocolate produced from different substitution for cocoa butter by Xanthan gum (XG) and Guar gum (GG) blends were determined using D-optimal mixture design. This study involved three levels of substitution which are 5%, 10% and 15% with constrained cocoa butter content and random blend of gums. Linear design models were applied to analyze parameters including texture (hardness) measurement and melting profile of fat crystal. Products experienced undesirable raises of hardness jointly with the increment of gums incorporation across the level of cocoa butter replacement from 5% to 15%. Similar trend was also agreed with the melting behavior of products as their melting point increased with the gradual diminution of cocoa butter. After all, the replacement of cocoa butter using hydrocolloids was deemed possible as there were products whose melting point and hardness fell in the acceptable range.
Pineapple waste is a by-product resulting from canning processing of pineapple that produce about 35% of fruit waste and lead to serious environmental pollution. Pineapple waste contains valuable nutrient components of simple sugar such as sucrose, glucose and fructose. Analysis of sugar content is important for further processing such as fermentation. The aim of this study was to determine the amount of sugar in different parts of pineapple waste (peel, core and crown) from variety N36. The selected pineapple waste for maturity indices 1, 2 and 3 was cut into small pieces before crushed in a food processor. The crushed waste was then filtered through muslin cloth followed by membrane filter 0.45μm to produce pineapple waste extract. Sugar content was determined using High Performance Liquid Chromatography. It was found that fructose content was significantly higher in core (2.24%) followed by peel (2.04%) and crown (0.87%). It was also found that glucose content was significantly higher in core (2.56%) followed by peel (2.18%) and crown (0.53%). Significant difference (p < 0.05) was found for sucrose content between pineapple core and peel extract with the value of 8.92% and 3.87%, respectively. However, sucrose was not detected in pineapple crown. It means that pineapple core extract had the highest values of fructose, glucose and sucrose compared to the other parts of pineapple waste extract. Besides, it was found that sucrose content was significantly higher in pineapple core for index 3 as compared to indices 1 and 2. Glucose and fructose was significantly higher in pineapple core for index 2 compared to indices 1 and 3.
Extraction of collagen from muscles of cultured catfish (Clarias gariepinus × C. macrocephalus) with the aid of pepsin digestion was investigated using a statistical tool. Fractional factorial design (FFD) was applied to evaluate the effects of eight process parameters: acetic acid concentration, acid extraction time, acid extraction temperature, acetic acid to muscles ratio, NaOH concentration, NaOH to muscles ratio, NaOH treatment time, and stirring speed. Contribution of every parameter in influencing the extraction efficiency was evaluated and factors that significantly affected the extraction were elucidated by employing experimental design and analysis of variance in FFD. The result of first order factorial design showed that acetic acid concentration, acid extraction time, acid to muscles ratio, and stirring speed had significant effect (P < 0.05) to the yield of pepsin soluble collagen (PSC) obtained at the end of the experiment. Effects of these process factors on the efficiency of collagen extraction were investigated, and are discussed in detail. Optimum conditions were found at 0.5 M acetic acid, 16 hr extraction period, solvent to muscles ratio at 25 ml/g, and stirring speed of 400 rpm, resulting in yield of PSC as high as 211.49 ± 15.51 mg/g.
MeSH terms: Analysis of Variance; Animals; Catfishes; Collagen; Muscles; Pepsin A; Research Design; Solvents; Temperature; Acetic Acid
Detection of enterotoxin by targeting entFM and hblA genes in Bacillus cereus BC1 strain inoculated into ready to eat food (RTF) and drink samples using polymerase chain reaction (PCR) was conducted. The B. cereus BC1 strain was confirmed as a Bacillus diarrhoeal enterotoxin (BDE) when tested by a commercially available Enzyme-linked immunosorbent assay-BDE immunoassay (ELISA-BDE immunoassay, TECRA). In the specificity study, both enterotoxin genes were detected on chromosomal DNA of B. cereus BC1 strain by showing a specific band of 1269 bp (entFM) and 874 bp (hblA), respectively. However, none of the target genes were detected for the other 15 genomic DNA bacteria (B. cereus (ATCC 11779), B. subtilis (ATCC 6633), Campylobacter jejuni (ATCC 29428), C. coli (Jabatan Kimia Malaysia, JKM), Clostridium perfringen (ATCC 13124), Enterobacter sakazaki (ATCC 51329), Escherichia coli (ATCC 43888), E. coli (ATCC 11735), Legionella pneumophila (ATCC 33152), Listeria monocytogenes (ATCC 35967), Salmonella typhi (IMR), S. enteritidis (ATCC 13076), S. typhimurium (ATCC 14028), Shigella flexeneri (ATCC 12022) and Vibrio cholerae bengal (Institute Medical Research (IMR), Malaysia) examined. The detection limit of both genes was 0.1 ng of genomic DNA. Thus, in the presence study it is evidence that the PCR analysis targeting enterotoxin of entFM and hblA genes are suitable and useful in detecting enterotoxic B. cereus in RTFs and drinks contaminated sample.
A study was carried out to observe the fermentation process for noni (Morinda citrifolia L.) extract by Saccharomyces cerevisiae. The experiment was based on a central composite rotatable design (CCRD) employing 5 center points with augmented axial and factorial points resulting in 30 runs. The M. citrifolia extract was fermented with different combination of substrate concentration (40, 50, 60, 70 and 80%) (w/v), inoculum size (0, 1.5, 3, 4.5 and 6%) (v/v), temperature (30, 33.5, 37, 40.5 and 44oC) and fermentation time (0, 1.5, 3, 4.5 and 6 days). Five physico-chemical characteristics which include pH, titratable acidity, turbidity, total soluble solids and total polyphenol content were measured. Results showed that all the responses could be well represented using statistical models. For pH, only fermentation time was found to be not significant, while for titratable acidity and total polyphenol content, the effects of substrate concentration and fermentation time were significant. The effects of inoculum size and temperature level were found to be significant for turbidity. For total soluble solids, only the effect of substrate concentration and inoculum size were found to be significant.
A total of 85 food handlers participated in this study to determine the hygienic status of their hands in primary schools located in the state of Selangor (Malaysia). Overall findings revealed that the fecal contamination and personal hygiene of the food handlers were well maintained with the range of mean bacterial counts from 0.18 to 0.47 log10 Colony Forming Units/cm2 during the three intervals of hand swabbing (before, during and after) preparation of ready-to-eat foods. However, the general indication of the microbiological quality (Aerobic Plate Count) was out of the standard (range of mean bacterial counts from 1.39 to 1.56 log10 Colony Forming Units/cm2) based on previous literature. This study highlighted that the food handler’s adherence to Good Manufacturing Practice and Sanitation Standard Operating Procedures was insufficient and suggested that attention should be emphasized on their practices at the intervals of school recess: before, during and after the preparation of ready-to-eat foods. In addition, there is also a need in the implementation of an effective HACCP program in Malaysia school foodservice operations.
The detection of tetrodotoxin (TTX) and saxitoxin (STX) in dried salted yellow puffer fish (Xenopterus naritus) eggs bought from Satok Market, Kuching, Sarawak was carried out by mouse bioassay method. The amount of TTX and STX detected in the samples ranged from 95.6-195.5 Mouse Unit (MU)/g and 1.72-3.58 MU/g respectively. The results indicate that the dried salted eggs samples were found to contain TTX 9-20 times above the regulatory limit for human consumption (10 MU/g). Although detected, the amount of STX in salted eggs extract was slightly below the accepted threshold limit (4 MU/g). The local public in Sarawak should be educated on the potential danger of consuming dried salted puffer fish eggs in addition to the current warnings on puffer fish.
A technique to isolate DNA from ghee was developed for the authentication of beef fat product. The method was based on pre-mixed ghee with phosphate buffer solution (PBS) prior to DNA extraction using Epicentre extraction method. The recovery of beef DNA was then analysed by polymerase chain reaction (PCR) using beef species-specific oligonucleotide primers which targeted the mitochondria DNA (mtDNA) of cytochrome b (cyt b) gene. The amplicon was 274 bp in size. The developed ghee extraction method offers a high yield of DNA providing 100 ng per μl and useful for validating beef fat product.
General phytochemical screening of the leaves of Saurauia roxburghii (Actinidiaceae) revealed the presence of alkaloids, flavonoids, glycosides, O-glycosides, terpenoids, carbohydrates, steroids, reducing sugar, tannins, phlobatannins and saponin are present in this plant whereas cardiac glycosides are absent. Two steroid compounds were isolated from the n-hexane extract of the leaves from S. roxburghii. Based on the spectral evidence IR, 1H-NMR and 13C-NMR, structures were determined to be stigmasterol (1) and β-sitosterol (2) This is the first report so far of occurrence and details spectroscopic description of these compounds from S. roxburghii.
Edible medicinal plants are often used in the treatment of various ailments and spice in traditional food preparation. In this study, 45 of tropical edible medicinal plants extracts from Indonesia, Malaysia, and Thailand were screened for their antimicrobial activity against five standard microorganisms for food preservative namely Aspergillus niger, Candida albicans, Escherichia coli, Pseudomonas aeruginosa and Staphylococcus aureus. The methanol extracts of Piper nigrum L. seed, Piper cubeba L. seed, and the root of Ligusticum acutilobum Siebold and Zucc. showed antimicrobial activity against five species of standard microorganisms. Among them, P. cubeba L. extract demonstrated the most susceptible against all tested microorganisms. Minimal inhibitory concentration (MIC) and minimal bactericidal or fungicidal concentration (MBC or MFC) were performed by the broth microdilution techniques as described by the Clinical and Laboratory Standard Institute. MIC values of P. cubeba L. extract to A. niger, C. albicans, E. coli, P. aeruginosa and S. aureus were 12.8, 1.6, 3.2, 6.4, and 1.6 mg/ml, respectively. P. cubeba extract killed A. niger, C. albicans, E. coli, P. aeruginosa and S. aureus with MBC values of 25.6, 3.2, 6.4, 12.8, and 3.2 mg/ml, respectively. The potent antimicrobial activity of P. cubeba L. extract may support its use for natural food preservative.
Malaysia depends on imports for its fragrant rice, mostly from Thailand, Vietnam, India and Pakistan. The fragrant rice farming in non-granary areas has been included in the new Entry Point Project (EPP) under the National Key Economic Areas (NKEA). In order to realize the aspiration of producing fragrant rice in large areas, it would require full participation and commitment from the existing and new farmers. The objective of this paper is to investigate farmer’s acceptance towards fragrant rice farming in two districts namely Pasir Mas and Tanah Merah, located in the state of Kelantan. The respondents of the study are 23 farmers and in-depth interviews are carried out to obtain farmers’ responses towards fragrant rice farming. The results from the content analysis reveal innovation characteristics, extension services and market pressure are among several factors that explain farmers’ acceptance towards fragrant rice farming.
This study explores the relationship between the total exports and total imports of the food industry in Sarawak from 1961 through 2007. We examined the sample period of the pre-1997 crisis (1961-1996) and the full sample period (1961-2007) to investigate disparities for pre-crisis sample. Analysis was carried out using standard econometric procedure and Dynamic OLS estimation for the annual observations of the two sample period. This study’s major findings are: (1) long run relationships were detected in the full sample period whereas they were absent in the pre-crisis period; (2) imbalances in food were found to be weakly sustainable for the full sample; (3) for every ringgit increase in imports, exports rose by RM0.803 for the full sample, revealing that imports grew at a rate faster than exports. This finding suggests that reducing the size of imports may improve imbalances in Sarawak’s food industry.
This study aimed to determine the effect of cooking on phytate content and the inhibitory effects of phytate on the bioavailability of minerals in eight Malaysian soy based dishes. Phytate was analyzed by using anion-exchange chromatography while minerals were analyzed by using Atomic Absorption Spectrophotometer. Molar ratios were obtained by dividing the mole of phytate to minerals. Phytate content was reduced in cooked dishes compared to the raw ones but it was not significantly different (P > 0.05). Raw, cooked and whole dish soy products contained 257.14-900.00, 182.14-803.57 and 289.29-910.71 mg/100 g phytate, respectively. Boiling and steaming have reduced most phytate content in the food samples. Molar ratios for phytate/minerals in these samples (phytate/Ca >0.17; phytate/Fe >1) indicated that phytate content inhibited the absorption of calcium and iron. However, the ratio for Ca × phytate/Zn in all samples was less than 200 which showed that phytate did not affect the bioavailability of zinc.
As Malaysian economies grow, Malaysian per capita income is likely to increase. From economics point of view, it is expected that better-off consumers will move to better quality of food attributes such as freshness, food safety, quality and healthfulness in their food intake. This study aimed to investigate the demand for eggs attributes by Malaysian consumers. The study considers the conjoint analysis technique as a method for acquiring insights into preferences for eggs product. The technique was applied to establish the trade-offs that Malaysian consumers make between size, colour, size of packaging, functional attribute and price in the purchasing of eggs for 202 respondents. Least squares regression was utilized to estimate the relative importance of attributes for eggs. The results revealed that the ideal characteristic of egg was one with large size (grade A), omega eggs, brown, and ten per packs. We also found that consumers were also willing to pay more for their preferred attributes. The results found in the study provide valuable inputs to producers or marketers to improve their marketing efforts as well as market positioning, in line with the demanded eggs attributes.
The central question to be examined in this study is associated with the value of the Malays traditional culinary practices of Malay chef in preparing the traditional food in Malaysian hotels. Present understanding highlighted that hotels are giving high priority on their superior services, such as luxury accommodations and intimate hospitalities. As such, promoting local foods in their dining establishment has taken a back seat. Research from past scholars indicated that hotel in Malaysia can be the one stop center for the local and international tourists to get the first hand information about local food specialities. On the hindsight, very limited efforts have been put into practice on the promotions of local food especially Malay cuisines in hotels. Main issue such as mass-produced Malay cuisines in the commercial kitchens, for example, should be highlighted to ensure that hotels are not jeopardizing the originality of traditional food preparations. Therefore, a qualitative reasearch focusing in in-depth interview with 10 Malay chefs was conducted in hotels around the Klang Valley. The results are so profound that majority of the Malay chefs under study shared similar understandings on technology advancements and modernizations that have taken place in their daily food preparations. Another finding revealed that one of the most challenging factors in preventing the Malay chefs to prepare the Malay food as it has been done traditionally is the attitude and awareness of the young generations to understand the values in traditional culinary practices. This study concludes with suggestion that aggressive knowledge sharing and information dissemination among the Malay chefs in hotels are needed to effectively market the traditional Malay food.
MeSH terms: Awareness; Malaysia; Social Change; Suggestion; Foods, Specialized; Information Dissemination
Tiger’s Milk mushroom has been used for medicinal purposes by local aborigines to treat asthma, breast cancer, cough, fever and food poisoning. Molecular phylogenetic analysis utilizing RNA polymerase II, second largest subunit (RPB2) gene, identified the wild Tiger’s Milk mushrooms collected from the state of Pahang in Malaysia for this study as Lignosus rhinocerus in the order Polyporales. The tuber, stipe and pileus of this mushroom were analyzed for their basic nutritional composition (fat, protein, and carbohydrate) and toxic metal content profile (Cadmium, Lead and Mercury). The moisture content of these mushroom parts varied from 32.22% (pileus) – 46.31% (stipe). The dry matter of the mushrooms contained 2.76% (stipe) – 6.60% (pileus) proteins, 0.21% (pileus) – 0.30% (tuber) fat, 1.76% (stipe) – 4.38% (tuber) ash and 38.47% (stipe) – 56.30% (pileus) carbohydrates. The toxic metal content of the mushroom samples ranged from 0.03–0.12 mg/kg for Cd, 0.80–1.94 mg/kg for Pb and 0.05–0.10 mg/kg for Hg. The present study demonstrated that L. rhinocerus is a potential source of food due to its high carbohydrate content. In addition, the trace levels of toxic metals in this mushroom are within the safe level for consumption.