In a bid to produce rice flour noodles with improved texture and reduced cooking time, rice flour-soy protein isolate noodles (RNS) were structurally enhanced by a combined treatment (COM) of microbial transglutaminase (MTG) with glucono-δ-lactone (GDL). The RNS-COM was either dried using superheated steam (SHS) to yield RNS-COM-SHS or steamed for 10 min (S10) before air drying to produce RNS-COM-S10 noodles. Control samples were SHS-dried rice flour (RN-SHS) and air-dried RN-S10 noodles. In general, textural and microstructural properties indicated higher textural properties and a more robust network in RNS-COM-SHS and RNS-COM-S10 than in other noodles. However, optimum cooking time (P < 0.5) was in the order; RN-SHS, RNS-COM-SHS < RN-S10 < RNS-COM-S10. As a result of the COM treatment, structurally enhanced noodles were more resistant to cooking. As applied in RNS-COM-SHS noodles, SHS was able to improve cooking quality, probably through the formation of bigger and evenly spread pores that had promoted faster gelatinisation of starch, with a high order of relative starch crystallinity.
Storage temperature and duration plays an important role in meat processing. Observations in poultry processing plants have shown a serious deviation in storage condition compared to the recommended procedures. Furthermore, there is still a paucity of evidence on the effects of storage temperature and duration on meat quality and microbial population. The aim of this study was to determine the effects of different temperature and duration during storage on physico-chemical properties and microbiological quality of broiler chicken Pectoralis major muscle. Eighty birds were slaughtered and processed, following which the packed boneless breast (PBB) (each bird was to provide two breast muscle samples; left breast and right breast) was divided into four groups, each consisted of 40 PBB. Each group was subsequently assigned to storage either at 4 °C, -10 °C, -18 °C or -40 °C, for 24 h before 20 PBB samples from each group were transported to the respective laboratory for meat quality and microbiological analysis. The remaining 20 PBB from each storage temperature were stored for 72 h before being transported for analysis. Results have shown significant increases in drip loss and cooking loss as the storage temperature decreases. Similarly, storage duration significantly affected cooking loss, of which, samples stored for 72 h exhibited higher cooking loss compared to those stored for 24 h. For color, significant differences were only observed in lightness (L*) and redness (a*) values. Longer duration of storage had significantly improved tenderness whereby, samples that have been stored for a shorter duration presented higher pH values. Populations of coliform and Salmonella decreased significantly with decreasing temperature and increasing storage duration.
Piper cubeba L. is traditionally recognised as flavouring ingredient in various types of foods and has been used to marinate meat. Scientifically, it has been reported to possess various valuable nutritional and pharmacological properties including antimicrobial potential. The aim of the present work was to determine the antibacterial activity of ethanolic P. cubeba L. extract against Escherichia coli and its effect on the microbiological quality of raw chicken meat during storage. Disc diffusion assay was done and resulted in 8.40 ± 0.10 mm of inhibition zone. The bacteriostatic and bactericidal effects of the extract were determined at 0.63 ± 0.00 mg/mL and 1.25 ± 0.00 mg/mL of concentration by MIC and MBC methods, respectively. The killing time was recorded at 2 × MIC (1.25 mg/mL) for 4 h. The application of the extract on chicken meat samples showed reduction in TPC and E. coli count with the observed optimum condition at 5.00% concentration stored at -18°C for 14 days based on the consistent reduction. Sensory attributes acceptability evaluation by 9-point hedonic scale showed acceptable score for colour, odour, texture and overall acceptability of the treated raw chicken meat samples. The findings implies that P. cubeba L. can be listed as one of the alternatives to reduce the bacterial load of raw chicken meat prior to cooking which is very important in ensuring food safety as well as reducing the occurrence of foodborne poisoning associated with chicken meat.
Supercritical carbon dioxide (SC-CO2 ) is a non-thermal technique implemented by food, pharmaceutical, and similar industries with the aim of inhibiting the microorganisms and apply effective sterilisation. Presently, limited number of studies has reported the application of SC-CO2 on fresh chicken meat. The present work therefore aimed to reveal the microbial and physicochemical quality of the SC-CO2 -treated fresh chicken meat. The fresh chicken meat was subjected to the SC-CO2 at 14 MPa and 45°C for 40 min and was stored at 4°C for 0, 3, and 7 days. The obtained results indicated that the treatment with SC-CO2 significantly decreased the total plate count and, yeast and mould count from log10 5.90 to 2.00 CFU/g and from log10 5.02 to 2.00 CFU/g at day 7 of storage, respectively. The values of pH, cooking loss, and water holding capacity were not affected by the treatment. The results revealed that the SC-CO2 -treated samples displayed harder texture, higher lightness and yellowness, and lower redness. In addition, lipid peroxidation of SC-CO2 and control samples resulted in values of 1.9 and 0.5 MDA/mg of meat at day 7 of storage time and did not significantly change in the rest of the evaluation days. In summary, the application of SC-CO2 was capable of enhancing the microbial quality and certain physicochemical attributes. However, alteration of certain parameters of SC-CO2 might enhance the overall meat quality.
Five different brands of Malaysian commercial beef frankfurters were analyzed for quality characteristics. The proximate contents showed significant differences among the samples. The range of moisture content was 63.0-73.9%; the protein content was 10.63-16.43% while the fat content was 1.71-12.22%. The lightness value (L*) of the uncooked frankfurters, which was in the range of 47.02-52.28, was significantly different among the samples. The lightness of the cooked frankfurters, showed a decrease in all the samples compared to the uncooked samples. No significant differences were observed for the folding test; where all samples showed no cracks after they were folded in half. However, significant differences were observed for the texture analysis. The hardness, cohesiveness, chewiness, springiness, gumminess and shear force ranged between 4.59-10.30 kg, 0.26-0.35, 16.15-51.72 kgmm, 12.73-14.79 mm, 1.17-3.49 kg and 1.67-7.08 kg respectively. The results of the study showed that Malaysian commercial beef frankfurters were significantly different in their physicochemical properties.
Chicken meat is widely consumed and it is the most common and popular poultry species in the world.The preference and consumption of chicken meat have been tremendously increasing in Malaysia. About 120 respondents who took part in the study were classified into four groups namely routine chicken eaters, chicken likers, chicken lovers with a health concern and real chicken lovers based on their preference and consumption of chicken meat. It is worthwhile to mention that the taste, price, and easy to cook were statistically significant between the four groups. In addition, race moderates the relationship with Malays dominating the chicken lovers’ category. It is interesting to observe that Malays prefer chicken meat with chilies, Chinese prefer chicken meat with sauce and Indians prefer chicken meat with salad.The findings of the study are useful to the broiler plants and agencies that are responsible in selling chicken meat. Further, the results may be used as a guide to the selection of chicken meat, and also to the restaurant owners in the selection of food to be offered to their consumers.
A total of 112 burger patties (35 beef burger patties, 39 chicken burger patties and 38 fish burger patties) which are commercially available at retail level were investigated for the presence and number of Listeria monocytogenes. These samples were analyzed using MPN-PCR method and conventional culturing methods. L. monocytogenes was detected in 33.3% of chicken burger patties, 22.9% of beef patties, and 10.5% of fish patty samples. From all contaminated raw burger patties, the estimated count of L. monocytogenes was ranged from 3 to 75 MPN/g. The results suggest that burger act as a potential source of listeriosis if the contaminated burger patty is consumed without adequate cooking. The risk associated with consumption of these samples was found to be high particularly for processed food at retail level in Malaysia. Therefore, food manufacturers play an important role in monitoring the manufacturing process and conduct a periodical surveillance on microbiological quality assessment on the processing plants. Besides, there is a need to increase awareness of consumers and food handlers to practice proper cooking of the burger patties before the point of consumption, to reduce the risk of listeria infection.
Omega-3 fatty acids have been shown to reduce the risk of chronic diseases like cardiovascular disease and cancer as well as promote brain development among infants and children. This study was carried out to compare total protein, fat and omega-3 fatty acids content of raw and pressurized fish of P. pangasius (yellowtail catfish) and H. macrura (long tail shad). The fish was cooked using pressure cooker for six minute to be pressurized. The protein content was determined by using Kjedahl method while total fat was determined using solvent extraction using chloroform and methanol. Fatty acid methyl esters (FAME) were prepared by a direct transesterification method, and quantified by gas chromatography using external standard. Results showed that marine fish H. macrura (long tail shad) had higher content (p < 0.05) of protein (18.30 ± 0.040 g/100 g), fat (10.965 ± 1.610 g/100 g), EPA (11.83 ± 0.02 g/100 g) and DHA (5.96 ± 0.31 g/100 g) compared to freshwater fish P. pangasius (yellowtail catfish). The protein content of pressurized fish was higher compare to raw fish, but there was no difference in total fat and omega-3 fatty acids content between raw and pressurized of freshwater fish P. pangasius and marine fish, H. macrura. In conclusion, marine fish are better source of protein, fat and omega-3 content, while pressurized fish shown to have comparable amount of protein, fat and omega-3 fatty acids content with raw fish. The result obtained assist the consumers to prepare a healthy menu in order to retain the protein and omega-3 fatty acids content of fish through healthy way of cooking.
This study evaluated the effects of different flours (tapioca, wheat, sago and potato) on the physicochemical properties of duck sausage. The examined physicochemical properties included proximate composition, cooking yield, color (lightness, redness and yellowness), folding, texture profile (hardness, elasticity, cohesiveness, gumminess and chewiness) and sensory properties. The study found that different flours have no effect on the cooking yield of duck sausage. The tapioca formulation showed a mid-range lightness value, folding score and textural properties. Duck sausages made with wheat flour had higher protein content and lightness value and a harder texture. Sausages made with potato flour had a darker color, the lowest folding scores and a softer texture. The addition of sago flour resulted in a higher folding score, greater elasticity and increased overall acceptability of sausage due to higher scores for texture and juiciness. These results show that the properties of duck sausage are influenced by the type of flour used.
Marination directly affects the texture and flavor of meat and is important for product yield. This research investigated the effects of various marinating solutions on the physicochemical, microstructural and sensory properties of golek chicken, a popular dish in Malaysia, Indonesia and southern Thailand. Non-marinated meat (Tr1-control) was compared with five marinating treatments: distilled water (Tr2); sodium chloride (Tr3); a mixture of sodium chloride and sodium tripolyphosphate (STPP) (Tr4); a mixture of sodium chloride, STPP and citric acid (Tr5); and a mixture of sodium chloride, STPP and sodium bicarbonate (Tr6). Marinating meat in Tr3–Tr6 resulted in higher water-holding capacity and cooking yield, as well as lower shear force value and cooking loss, when compared to Tr1 and Tr2 (p
The advantage of cooking cannot be summarized just as the better food digestion. Some investigations showed the effect of cooking on reduction of food anti-nutrients such as oxalate. This study was aimed to determine the effect of cooking on oxalate content and its negative effects on calcium availability in eight Malaysian soy-based dishes. Since there is few data which examined the effects of cooking on food oxalate content globally, thus this study was designed as the first in Malaysia. Oxalate in this research was analyzed by using enzymatic methods, while calcium content was determined by using Atomic Absorption Spectrophotometer. The oxalate concentration was in the range of 6.43-19.40 mg/100 g for whole cooked samples, 9.03-11.90 mg/100 g for raw soy products, and 4.36-7.99 mg/100 g for cooked ones. There were 5 out of 12 samples containing oxalate, which was significantly lower (p < 0.05) in cooked products compared to the raw ones. The rest of the samples were also lower in oxalate but not significantly different (p > 0.05). Oxalate in raw/cooked fermented soy products (tempeh) was slightly lower compared to the non-fermented ones. However, there was no significant difference (p > 0.05) in oxalate amount between fermented and non-fermented soy products. As Oxalate/Calcium ratio was below 1, oxalate did not have an effect on availability of calcium in the studied samples. Optimal cooking and food processing might be effective in reducing oxalate content in soy products. There is a need for more investigations about the effect of cooking on soy products to confirm the present results.
Bacillus cereus (B. cereus) isolates are toxigenic and can cause food poisoning. Cooked rice is
a potentially hazardous food, especially in tropical countries. The aim of this study was to determine the prevalence of B. cereus and B. thuringiensis in raw and cooked rice marketed in Selangor, Malaysia. In this research combination of Most Probable Number - Polymerase Chain Reaction (MPN-PCR) was used to detect gyrB gene in B. cereus and B. thuringiensis. Five local varieties of raw rice samples were negative for B. thuringiensis but all (100%) were positive for B. cereus. A total of 115 cooked rice samples (nasi lemak, nasi briyani, nasi ayam and nasi putih) were studied for the presence of B. cereus and B. thuringiensis. Nasi ayam was found to have the highest prevalence (100%) of B. cereus compared to nasi putih (76.2%) and nasi lemak (70.4%). Nasi briyani had the lowest prevalence (50%) of B. cereus. The frequencies of B. thuringiensis were found to be 10, 30 and 35.2 % in nasi putih and nasi ayam, nasi briyani and nasi lemak, respectively. The range of B. cereus and B. thuringiensis in the samples was from < 3 to 1100 MPN/g in different samples. Maximum number of B. cereus was observed in nasi lemak, nasi briyani and nasi putih ( > 1100 MPN/g) while nasi ayam showed less contamination (460 MPN/g) with B. cereus which was significantly different (P < 0.05 ) from others. The number of B. thuringiensis in nasi lemak, nasi briyani, nasi putih and nasi ayam were found to be >1100, 93, 9.2 and 3.6 MPN/g, respectively.
Unripe and ripe kundang fruits (Bouea macrophylla Griffith) is either consumed fresh or is cooked in Malaysia. In this study composition of unripe and ripe fruits (proximate, amino acids profile, minerals and heavy metal contents) were evaluated. Results obtained showed unripe kundang fruit to possess higher moisture, ash, crude lipid, crude fiber and crude protein contents than the ripe fruits. With regard to amino acid contents, unripe fruits had higher content of essential amino acids. The unripe and ripe fruits were found to be rich in essential minerals with potassium (K) to be in abundance. Heavy metals such as cadmium, nickel, mercury, lead and arsenic, were detected in trace amounts (< 5.0 mg/kg) in both unripe and ripe fruits. Through this investigation, it is concluded that both unripe and ripe fruits to posses’ adequate amount of nutritionally important compounds beneficial to human health and can be explored for commercial purposes.
The aim of this study was to determine the effects of xanthan gum and carrageenan on the
oil uptake and acceptability of banana (Musa acuminate) fritters during repeated deep fat
frying. Banana namely ‘Pisang Awak’ at maturity stage 6 were peeled, cut and dipped into 3
batter formulations containing 1% carrageenan, 1% xanthan gum and a control. The bananas
were deep fried at 170±5°C for 3 minutes in 2.5L cooking oil without oil replenishment for
3 consecutive days. The moisture, oil content, texture, colour and acceptability of the banana
fritters were evaluated at first and every 10th frying cycles. Results indicated that the oil and
moisture content of fried bananas were dependent on frying cycles. The oil content increased
while the moisture decreased with increased in frying cycles. There was significant reduction
(p0.05) in terms of overall acceptance between
treated and untreated. Hence, 1% xanthan gum was effective in reducing oil absorption of
banana fritters without affecting the overall sensory acceptability
Ulam or traditional vegetables in Malaysia comprise more than 120 species representing various
families ranging from groundcovers, shrubs to trees. The leaves, shoots, flowers, fruits, roots and rhizomes of the vegetables are eaten fresh as salad or cooked and are consumed to add variety and flavor to the diet, as well as for their health benefits. Ulam species are rich in carbohydrate, protein, mineral and vitamin. This study established that ulam species differ greatly with respect to types and concentrations of carotenoids in leaves. A total of 10 species were evaluated for quantitative and qualitative carotenoid composition through spectrophotometry and HPLC analysis. The main carotenoids identified in these selected ulam were lutein, neoxanthin, violaxanthin, zeaxanthin and β-carotene. The ratio of these carotenoids varies between species.
In the present study, six different rice varieties marketed in Penang, Malaysia (locally grown and imported) were evaluated for proximate composition, physiochemical properties and cooking qualities. Overall, 'Black rice' variety had the highest protein content (8.16%) with lowest fat content (0.07%). Between the various rice varieties investigated, thousand kernel weight varied between 16.97-19.43 g, length/breadth (l/b) ratio was between 2.09-3.75, while bulk density varied between 0.81-0.86 g/ml. Amylose content was highest (27.71%) in white rice (local, medium grain type) with lowest recorded for brown rice variety (3.36%). Results on minimum cooking time showed it to range between 10 to 31.67 minutes with the brown rice cooking the slowest. The water uptake ratio ranged between 2.33 to 3.95 and was low in glutinous rice (2.33), while gruel solid loss (range from 3.17 to 6.43) was lowest in Basmati rice variety (3.17%). The minimum cooking time was found to be negatively correlated with amylose content (r = -0.97). A positive correlation was recorded for both amylose content and l/b ratio in relation to elongation of cooked rice. These results highlight cooking and physiochemical properties of rice to be strongly dependent on their amylose content. Results generated in this study might be able to provide vital information's on identifying 'superior quality of rice' marketed in Penang, based on their proximate composition as well as on their physiochemical and cooking properties.
The objectives of this study were predicting the transmission and survival of L. monocytogenes in cooked ham during supply chain. Cooked ham are frequently contaminated with L. monocytogenes during postprocessing steps through contact on surface of processing, handling, packaging equipment. Transfer rate of L. monocytogenes on static and dynamic condition in various surface type was investigated. The prevalence and level of L. monocytogenes in cooked ham at plant as well as the prevalence of unsatisfactory processing at retail were studied. A Monte Carlo simulation model was created by using @risk. The simulation predicted that the prevalence was 11.76 % with 90% confidence interval of 2% to 25% and estimated level was -4.02 log CFU/cm2. It was estimated to be occurred on slicing step at plant. Our results suggest that, the prevalence and level of L. monocytogenes can be reduced by Good Handling Process application and/or HACCP application.
Duck feet collagen was added to threadfin bream and sardine surimi to study its effect on physicochemical properties such as folding test, gel strength, cook loss, water holding capacity, expressible moisture, texture profile analysis and colour measurement. As compared to commercial fish scale collagen and cow collagen, the addition of duck feet collagen resulted in a significant improvement in the quality of the sardine surimi. Duck feet collagen was able to improve the folding test score of sardine surimi from 3.00 to 5.00; gel strength was increased from 275.70 g.mm to 2682.70 g.mm and hardness of gel was increased from 1.12kg to 6.00kg. Addition of duck feet collagen improved the gel strength of threadfin bream surimi from 1696.70 g.mm to 5579.40 g.mm and hardness of gel was increased from 4.55kg to 10.32kg. Colour of threadfin bream and sardine surimi also improve with the addition of duck feet collagen. The lightness was increased from 66.47 to 66.89 (threadfin bream) and from 62.32 to 63.60 for sardine. The results suggest that duck feet collagen has potential as an alternative source of protein additive for the improvement of the physicochemical properties of low grade surimi.
Green leafy vegetables are good sources of carotenoids. Generally, food composition databases related to raw foods are available, but data on cooked foods in Malaysia are still lacking. Since carotenoids are prone to degradation during cooking processes, the present study was undertaken to evaluate the extent of nutrient loss in vegetables subjected to two conventional cooking methods, which were boiling and stir-frying with cooking durations of 4 and 8 minutes. The vegetables selected were Chinese cabbage (Brassica Pekinensis var. cephalata), swamp cabbage (Ipomoea aquatica), spinach (Spinacia oleracea), Ceylon spinach (Basella rubra), red spinach (Amaranthus gangeticus), white spinach (Amaranthus viridis) and tapioca shoots (Manihot utilissima). Percentage losses of nutrients after cooking treatment were calculated based on retention factors. Results obtained showed that stir-frying had reduced lutein content for all vegetables ranging from 8-89% while the effect of boiling for lutein varied (0-428%) with different vegetables at both cooking durations of 4 and 8 min. Boiling for 8 min increased retention of β carotene in all vegetables ranging from 18-380% except for Chinese cabbage and spinach compared with 4 min, while stir-frying generally increased the retention of β-carotene for all vegetables 2-3 times except for spinach. Cooked vegetables have variations in carotenoids composition brought by varying cooking conditions (time and temperature), type of vegetables and the interaction between cooking methods and type of vegetables.
The influence of superheated steam cooking on fat and fatty acid composition of chicken sausage were investigated at various temperatures (150, 200, and 250°C) with different time domains (2-6 min). It has been found that the fat content of raw sample was higher than that of all cooked samples. The total fat content of cooked sample, showed a linear decreasing with time at all investigated temperatures. Superheated steam produce changes in saturated fatty acid (SFA), monounsaturated fatty acid (MUFA), and polyunsaturated fatty acid (PUFA) in which their values were found to decrease in cooked samples. When different cooking conditions (temperature, time) were applied, the fatty acids were decreased as the time and temperature increased. The PUFA and MUFA were less prone to decrease at 150°C, while at this temperature there was a remarkable loss in SFA content. This cooking method considerably reduced the level of fat and SFA which have a positive effect on health. In addition it could imply a great choice for consumers to choose the healthier technique for cooking food.