The extraction method for the determination of ochratoxin A (OTA) in black pepper was optimized. The influence of three variables, i.e., type of solvent, solvent-volume-to-sample- size ratio (v/w) and amount of sodium chloride (NaCl) (g), on OTA recovery was evaluated. Analysis of variance was used to compare recovery values obtained from different solvents, and response surface methodology (RSM) was used to determine the optimum amount of NaCl and the solvent-volume-to-sample-size ratio. The concentration of OTA was determined by high-performance liquid chromatography with fluorescence detection. The highest recovery (95.2 %) was obtained when methanol/water (80:20, v/v) was used as the solvent. The RSM results showed that the experimental data could be adequately fitted to a second-order polynomial model with multiple regression coefficients (R2) of 0.962. The optimum amount of NaCl was determined to be 3 g, whereas the optimum solvent-volume-to-sample-size ratio (v/w) was found to be 4. The proposed method was applied to 20 samples, and the presence of OTA was found in 8 (40%) samples ranging from 0.11 to 3.16 ng g-1.
Coconut oil (CNO) is a vegetable fat that can be applied as a cocoa butter substitute (CBS) due to its similar physical characteristics to cocoa butter. However, it must be fractionated or hydrogenated to be used as CBS. The aims of the present work was to fractionate CNO using supercritical fluid extraction (SFE), and determine the potential fraction which is suitable as CBS. CNO was fractionated by SFE at 48.3 MPa and 80°C into four different fractions, F1, F2, F3 and F4. Fraction 1 had the highest yield (48.9%) as compared to the other fractions. Fraction 4 had the lowest content of lauric acid, C12 (31.12%) and the highest amount of palmitic acid, C16 (16.43%); stearic acid, C18:0 (4.99%); and linoleic acid, C18:1 (17.44%). Fraction 4 also had the highest melting profile (25.24°C) and amount of solid fat content (state) closest to CB. Therefore, F4 was selected as a potential fraction for the application of CBS. This finding reveals that CNO can be fractionated by SFE and applied as CBS to help diversify the application of coconut products.
Grinding is an important factor in espresso coffee preparation and the optimal grinding level is needed to improve its characteristics. However, a problem arises where ground cocoa nibs change from solid to fluid mass at finer level due to high fat content (52%) in the cocoa bean. Thus, the aim of this study was to determine the effect of fat in Ivory Coast cocoa nibs and grinding level on particle size and the physicochemical characteristics including viscosity (mPa), pH, foam index (%), density (g/mL), total solid (mg/mL) and extraction (%) of espresso cocoa (ECOC). Solvent extraction was used to produce defatted cocoa nibs (40%, 34% and 20%) and was ground at four different grinding levels (i.e., 10, 30, 50 and 70) to extract a cup of ECOC using espresso machine. The grinding level 70 (1665.0±28.30 μm) contributed to significantly (p
Allergy caused by food is usually type 1 allergy of four types of allergic reactions. One of the most widespread allergic is those that are caused by crustacean shellfish. Crustaceans are classified among arthropods which include crab, crayfish, lobster, prawn and shrimp. Shrimp which are broadly consumed as nutritional food is one of the most important food that contribute to allergy. Thus, reducing the allergenicity of shrimp allergen will be helpful to individuals who are sensitive to shrimp and for this reason the characteristics of each allergen need to be studied. Those sensitized individuals can develop urticaria, angiodema, laryngospasm, asthma and life threatening anaphylaxis. To date, four main allergens contribute to allergic reactions. They are tropomyosin (TM), a highly conserved and heat stable myofibrillar protein of 35-38 kDa followed by arginine kinase (AK) which is also known as Pen m 2 or Lit v 2 with 40 kDa. Two other contributing allergens are sarcoplasmic calcium-binding protein (SCP) also known as Lit v 4 with 22 kDa and myosin light chain (MLC) which is also termed as Lit v 3 with 20 kDa. This mini-review will provide a better understanding of each allergen derived from shrimp which subsequently will help to reduce the allergenicity.
Cocoa beans are rich in numbers of beneficial bioactive compounds such as phenolics and
phytosterols, which benefits to human being. The suitable extraction method is needed to
produce high quality and quantity of cocoa butter and other bioactive compounds. There are
many extraction method to extract these compounds such as Soxhlet extraction, supercritical
fluid extraction, ultrasound extraction method and others. The objective of this study is to
determine the effectiveness of the different extraction methods producing high yields of cocoa
butter, lower oxidative value, stable phytosterols and antioxidant content. The cocoa beans were
subjected to different extraction methods such as Soxhlet extraction (SE), Ultrasonic extraction
method (USE), Supercritical carbon dioxide (SCO2
) and Supercritical carbon dioxide with cosolvent
(SCO2
-Ethanol). Cocoa butter extracted using SCO2
-Ethanol has significantly (p
Nanotechnology contribute to significant impacts in every way in our daily life. Recently,
the application of nanotechnology in biosensors has been a trend in developing a highly
sensitive, selective, quick response, inexpensive, high volume production, great reliability
and miniaturized sensors. High demands on the production of rapid sensors for food safety
and quality control purposes are increasingly become the interest for researchers all over the
world. This is because, in food sector, the quality of a certain product is based on their periodic
chemical and microbilogical analysis. The uses of nanomaterials in biosensors are very
promising because they mediate current flow. Surface modification of the electrode based on
various nanomaterials including nanoparticle, nanofiber, nanowire and nanotube significantly
increase the performance of the biosensor. Ultimately, this implementation will enhance the
sensor’s sensitivity and stability. This review explores the previous research and development
work on nanomaterials-based sensors for food applications.
This study was carried out to extract and compare the characteristic ability of globulins from cottonseed, alfalfa seed, pea seed, mung bean and French bean with cocoa seeds to produce cocoa-specific aroma precursors. The extracted globulins were compared through SDS PAGE, amino acid and oligopeptide profiles. A very low recovery was obtained during globulin extraction from different seeds ranging from 0.5% to 2.7%. Cottonseed produced the highest total protein (13.90 mg/g), followed by cocoa seed (11.91 mg/g), whereas alfalfa seed, mung bean, pea seed and French bean produced 7.86, 4.77, 4.59 and 3.89 mg/g respectively. Two distinctive bands of 51.1 and 33.0 kDa were observed for cocoa vicilin-class globulin (VCG) from SDS PAGE. More than three bands were shown for other seed globulins. Comparative HPLC analyses of the obtained peptide mixtures revealed different and complex patterns of predominantly hydrophobic peptides. A similar high content of amides (glutamic acids-glutamine, aspartic acid- asparagine and arginine) and low concentrations of lysine were observed in all seeds globulin.
Sulfonamides (SAs), synthetic antibiotics, are commonly used by veterinarians in chicken for therapeutic, prophylactic or as growth promoter and halt the growth of bacteria in animal production. Four common SAs, Sulfadiazine (SDZ), Sulfamethazine (SMZ), Sulfamethoxazole (SMX) and Sulfaquinoxaline (SQX), were determined in chicken breast and liver samples using reverse phase HPLC using UV detector at 266nm. The concentration of SAs detected in samples from 11 states in Peninsular Malaysia ranged from 0.006-0.062 µg/g in breast meat samples and 0.08-0.193 µg/g in liver samples. Except for sample from Johor, concentration of SAs in all the samples were lower than MRLs established by Malaysia (0.1 µg/g). Exposure of sulfonamides in Malaysian consumers ranged from 0.002-0.088 µg/kg body wt. /day. The highest value of sulfonamides exposure was found in Johor with an estimated daily intake (EDA) of Sulfamethoxazole (SMX) in Johor.
The whole plant extract of plant Sceletium tortuosum, plant native to South Africa, has been known
traditionally to have mood enhancing and stimulant properties. These properties have been confirmed before by proving serotonin-uptake inhibition activity. A further confirmation by using CB1 receptor binding assay has been performed in this study. The unfermented alkaloid extract was proved to posses a higher activity to bind CB1 receptor compared to that of the fermented one. GC-MS analysis confirmed that unfermented alkoloid extract contain more alkaloids than the fermented one. The ethanol extract was also more active than the fermented one, suggesting that non-alkaloid compounds in this extract could posses this activity. An additional test to check wether this extract can improve cognitive function and memory was performed by acetylcholinesterase inhibitory assay. Both fermented and unfermented alkaloid extracts could inhibit acetylcholinesterase with IC50 being 0.303 mg/ml and 0.330 mg/ml, respectively. However, the major alkaloid in the extract, mesembrine, did not show inhibition of the enzyme. A TLC based test proved that other alkaloids in the extract were responsible to the activity.
Fried and baked banana-based snacks are popular in South East Asia and banana chip is popular in
other countries, such as India, Indonesia, China, African countries, etc; these snacks may contain acrylamide in concentration which may be of concern due to its toxicity. This study was carried out to determine acrylamide concentration in popular banana based snacks in Malaysia using a modified method of gas chromatographymass spectrometry. The limit of detection and limit of quantitation of the modified method are 5 and 15 μg/kg, respectively. Acrylamide concentration of five types of Malaysian popular fried and baked banana based snacks from different local markets ranged from 74.0 to 7468.8 μg/ kg for banana fritter (pisang goreng), 28.9 to 243.7μg/kg for banana chips (kerepek pisang), 160.7 to 500.4 μg/kg for sweet banana chips (kerepek pisang manis), not detected to 154.4 μg/kg for banana cake (kek pisang) and 31.7 to 609.1 μg/kg for banana balls (cekodok pisang). Analysis of variance showed a significant difference (P
An acidic solution containing mercury chelating agents to eliminate mercury in raw fish (mackerel) fillet was developed. The solution contained hydrochloric acid, sodium hydroxide, cysteine, EDTA, and NaCl. The optimum conditions for mercury reduction were achieved using response surface methodology (RSM) at cysteine concentration of 1.25%, EDTA of 275 mg/L, NaCl of 0.5%, pH of 3.75, and exposure time of 18 min. The optimized conditions produced a solution which can remove up to 91% mercury from raw fish fillet. Cysteine and EDTA were identified as potential chelating agents with the greatest potential for use. The solution can be employed in fish industries to reduce mercury in highly contaminated fish.
A simple method for the reduction of aflatoxins B₁ (AFB₁), B₂ (AFB₂), G₁ (AFG₁), G₂ (AFG₂) and ochratoxin A (OTA) in white pepper was studied. Response surface methodology (RSM) was applied to determine the effect of four variables, which included time (20-60 min), temperature (30-70°C), calcium hydroxide (Ca(OH)₂) (0-1%) and hydrogen peroxide (H₂O₂) (1-3%) during the washing step of white pepper. The efficacy of the method was evaluated by the determination of mycotoxins by HPLC with fluorescence detection (FD). Statistical analysis showed that the experimental data could be adequately fitted into a second-order polynomial model, with a multiple regression coefficient (R²) in the range of 0.805-0.907 for AFG₂ and AFG₁, respectively. The optimal condition was 57.8 min, 62.0°C, of 0.6% (w/v) and 2.8% (v/v) for time, temperature, Ca(OH)₂ and H₂O₂ respectively. By applying the optimum condition, the mycotoxins reduction was found to be in the range of 68.5-100% for AFB₂ and AFG₁ respectively.
Umami, the fifth basic taste, is the inimitable taste of Asian foods. Several traditional and locally prepared foods and condiments of Asia are rich in umami. In this part of world, umami is found in fermented animal-based products such as fermented and dried seafood, and plant-based products from beans and grains, dry and fresh mushrooms, and tea. In Southeast Asia, the most preferred seasonings containing umami are fish and seafood sauces, and also soybean sauces. In the East Asian region, soybean sauces are the main source of umami substance in the routine cooking. In Japan, the material used to obtain umami in dashi, the stock added to almost every Japanese soups and boiled dishes, is konbu or dried bonito. This review introduces foods and seasonings containing naturally high amount of umami substances of both animal and plant sources from different countries in Asia.
The objective of this study was to examine the effect of washing pre-treatment on mercury concentration in fish fillet. Response surface methodology was used to investigate the influence of three variables, pH (1-6.5), NaCl (0-1% w/v) and exposure time (5-30 min) by using a three-factor central composite design. The aim was to obtain the best possible combination of these variables in order to reduce mercury in fish fillet. The experimental data were adequately fitted into a second-order polynomial model with multiple regression coefficients (R(2)) of 0.961. The results indicated that the reduction of mercury in fish flesh significantly depends on the pH of the solution used. The overall optimal condition resulting in the maximum mercury reduction in fish fillet was obtained at a combined level pH of 2.79, NaCl of 0.5% and exposure time of 13.5 min. The optimized protocol produced a solution that can reduce mercury from raw fish fillet up to 81%.
This article reviews application of glutamate in food and its benefits and role as one of the common food ingredients used. Monosodium glutamate is one of the most abundant naturally occurring amino acids which frequently added as a flavor enhancer. It produced a unique taste that cannot be provided by other basic taste (saltiness, sourness, sweetness and bitterness), referred to as a fifth taste (umami). Glutamate serves some functions in the body as well, serving as an energy source for certain tissues and as a substrate for glutathione synthesis. Glutamate has the potential to enhance food intake in older individuals and dietary free glutamate evoked a visceral sensation from the stomach, intestine and portal vein. Small quantities of glutamate used in combination with a reduced amount of table salt during food preparation allow for far less salt to be used during and after cooking. Because glutamate is one of the most intensely studied food ingredients in the food supply and has been found safe, the Joint Expert Committee on Food Additives of the United Nations Food and Agriculture Organization and World Health Organization placed it in the safest category for food additives. Despite a widespread belief that glutamate can elicit asthma, migraine headache and Chinese Restaurant Syndrome (CRS), there are no consistent clinical data to support this claim. In addition, findings from the literature indicate that there is no consistent evidence to suggest that individuals may be uniquely sensitive to glutamate.
Mycotoxin toxicity occurs at very low concentrations, therefore sensitive and reliable methods for their detection are required. Consequently, sampling and analysis of mycotoxins is of critical importance because failure to achieve a suitable verified analysis can lead to unacceptable consignments being accepted or satisfactory shipments unnecessarily rejected. The general mycotoxin analyses carried out in laboratories are still based on physicochemical methods, which are continually improved. Further research in mycotoxin analysis has been established in such techniques as screening methods with TLC, GC, HPLC, and LC-MS. In some areas of mycotoxin method development, immunoaffinity columns and multifunctional columns are good choices as cleanup methods. They are appropriate to displace conventional liquid-liquid partitioning or column chromatography cleanup. On the other hand, the need for rapid yes/no decisions for exported or imported products has led to a number of new screening methods, mainly, rapid and easy-to-use test kits based on immuno-analytical principles. In view of the fact that analytical methods for detecting mycotoxins have become more prevalent, sensitive, and specific, surveillance of foods for mycotoxin contamination has become more commonplace. Reliability of methods and well-defined performance characteristics are essential for method validation. This article covers some of the latest activities and progress in qualitative and quantitative mycotoxin analysis.
Supercritical carbon dioxide extraction (SC-CO2) of bioactive flavonoid from Strobilanthes crispus (Pecah Kaca) was performed to study the effects of various parameters such as pressure, temperature and dynamic extraction time on the yield and composition of bioactive flavonoid. The results were also compared with those obtained by conventional Soxhlet extraction in lab conditions. The results from SFE showed that the effect of extraction variables on extraction yields decreased in the following order: pressure, temperature and dynamic extraction time. The extraction pressure played a dominant role in the yield of the sample while the effect of time could be ignored. This study also revealed that both Soxhlet extraction and SC-CO2 extraction can be used to obtain flavonoid compound. Under the optimum conditions, the highest bioactive flavonoid compound content was obtained at 3.98% and eight flavonoid compounds were identified by HPLC.
The growth of the Malaysian’s per capita income has generally empowered consumers to have more choices for food, more purchasing power, health consciousness and demand for more nutritional values of their food intake. Motivated by the changes in Malaysian consumer’s food choice, a conjoint analysis was performed to investigate Malaysian consumers’ demand for rice attributes and how much consumers are willing to pay for the demanded attribute. A conjoint analysis is a method used in identifying and understanding the combined effects of product attributes on preferences for a product or service. In conjoint analysis, utility is the conceptual basis for assessing the value of a product or service, where individuals make decisions between bundles of products based on their budget constraints. The findings suggested that the most important attribute for rice was food safety, followed by taste and size of grain. Consumers were also willing to pay premium prices for the demanded attributes. The findings would have positive implications for the agrifood industry if it responds effectively to translate into business opportunities to these changes.
The objective of this study is to investigate the demand for quality vegetables in Malaysia. This study estimates quality elasticities from the difference between expenditure and quantity elasticities in order to show the demand for quality vegetables in Malaysia. By using the Household Expenditure Survey 2004/2005, expenditure and quantity Engel equations are estimated via two stage least square. The positive estimated quality elasticities (except root and tuberous vegetable) show that Malaysian consumers tend to increase their demand for quality vegetables in response to their incomes rise. To be more specific, urban consumers are expected to demand more of higher quality vegetables (except root and tuberous vegetable) than rural consumers.
As Malaysian economies grow, Malaysian per capita income is likely to increase. From economics point of view, it is expected that better-off consumers will move to better quality of food attributes such as freshness, food safety, quality and healthfulness in their food intake. This study aimed to investigate the demand for eggs attributes by Malaysian consumers. The study considers the conjoint analysis technique as a method for acquiring insights into preferences for eggs product. The technique was applied to establish the trade-offs that Malaysian consumers make between size, colour, size of packaging, functional attribute and price in the purchasing of eggs for 202 respondents. Least squares regression was utilized to estimate the relative importance of attributes for eggs. The results revealed that the ideal characteristic of egg was one with large size (grade A), omega eggs, brown, and ten per packs. We also found that consumers were also willing to pay more for their preferred attributes. The results found in the study provide valuable inputs to producers or marketers to improve their marketing efforts as well as market positioning, in line with the demanded eggs attributes.