This article reports on the changes of oxidation indices and minor components of low free fatty acid (FFA) and freshly extracted crude palm oils after storage at ambient (28 ± 1 C) and 60 C for 77 days. The changes in peroxide value (PV), FFA, extinction coefficient at 233 and 269 nm (K233 and K269), bleachability index (DOBI), carotene and vitamin E contents were monitored. PV, FFA, K233 and K269 of both oil samples increased as storage progressed while the values of carotene and vitamin E contents decreased. At the end of storage period at 60 °C, the carotene content of low FFA crude palm oil was 4.24 ppm. The storage conditions used led to the loss of entire vitamin E fractions of both oil samples as well as a reduction in DOBI values except for freshly extracted crude palm oil stored at ambient temperature.
A study to measure frying quality and stability of rice bran oil (RBO) compared to palm olein (PO) was conducted. The oils were used to fry French fries continuously for six hours a day up to five days at a temperature of 185 ± 5°C. Oil samples were collected and analyzed for free fatty acid (FFA), peroxide value (PV), smoke point, p-anisidine value (p-AV), iodine value (IV) and colour. At the end of the frying period for both oil samples, FFA, PV, colour and p-AV were increased whereas the IV and smoke point decreased. The rate of FFA formation of RBO was slightly lower which increased from 0.142% to 0.66% compared to PO which was from 0.079% to 0.93%. The PV of RBO showed consistent increased from 3.9 meq/kg to 13.4 meq/kg whereas PO with initial value at 3.4 meq/kg increased to 34.6 meq/kg on the fifth day. Smoke point of RBO and PO progressively dropped from 235°C to 188°C and 220°C to 178°C, respectively. The level of p-AV for RBO increased from 12.19 to 32.65 from the initial to the end of frying day whereas PO had higher rate of changes in p-AV which was from 10.45 to 60.75. The IV decreased over frying time where IV of RBO decreased from 94.5 to 66.5 while IV of PO decreased from 50.9 to 44.6. The colour of RBO showed increased in redness and yellowness but PO was darker at the end of the frying trial. In general, RBO showed better stability than the PO in deep frying of French fries.
Lactococcus lactis subsp. cremoris MG1363 is an important starter culture for dairy fermentation. During industrial fermentations, L. lactis is constantly exposed to stresses that affect the growth and performance of the bacterium. Although the response of L. lactis to several stresses has been described, the adaptation mechanisms at the level of in vivo fluxes have seldom been described. To gain insights into cellular metabolism, 13C metabolic flux analysis and gas chromatography mass spectrometry (GC-MS) were used to measure the flux ratios of active pathways in the central metabolism of L. lactis when subjected to three conditions varying in temperature (30°C, 37°C) and agitation (with and without agitation at 150 rpm). Collectively, the concentrations of proteinogenic amino acids (PAAs) and free fatty acids (FAAs) were compared, and Pearson correlation analysis (r) was calculated to measure the pairwise relationship between PAAs. Branched chain and aromatic amino acids, threonine, serine, lysine and histidine were correlated strongly, suggesting changes in flux regulation in glycolysis, the pentose phosphate (PP) pathway, malic enzyme and anaplerotic reaction catalysed by pyruvate carboxylase (pycA). Flux ratio analysis revealed that glucose was mainly converted by glycolysis, highlighting the stability of L. lactis' central carbon metabolism despite different conditions. Higher flux ratios through oxaloacetate (OAA) from pyruvate (PYR) reaction in all conditions suggested the activation of pyruvate carboxylate (pycA) in L. lactis, in response to acid stress during exponential phase. Subsequently, more significant flux ratio differences were seen through the oxidative and non-oxidative pentose phosphate (PP) pathways, malic enzyme, and serine and C1 metabolism, suggesting NADPH requirements in response to environmental stimuli. These reactions could play an important role in optimization strategies for metabolic engineering in L. lactis. Overall, the integration of systematic analysis of amino acids and flux ratio analysis provides a systems-level understanding of how L. lactis regulates central metabolism under various conditions.
In this study, potassium oxide supported on dolomite adsorbent was used as an adsorbent for free fatty acids (FFAs) treatment in crude palm oil (CPO). The characteristics of the adsorbent were determined by TGA, XRD, SEM, BET and TPD-CO2. Taguchi method was utilized for experimental design and optimum condition determination. There were four parameters and three levels involved in this study: time (30, 60, 90 min), stirring rate (300, 500, 700 rpm), adsorbent dosage (1, 3, 5 wt%) and K2O concentration (5, 10, 15 wt%). The adsorbent had a larger pore size, higher basic strength, and more basic sites in greater efficiency (63%) in FFAs removal from CPO. The optimum conditions were at 30 min time, 700 rpm stirring rate, 5 wt% adsorbent dosage and 15 wt% K2O concentration. Taguchi method simplified determination of experimental parameters and minimized the operating costs.
Initially, a new moderate halophilic strain was locally isolated from seawater. The partial 16S rRNA sequence analysis positioned the organism in Marinobacter genus and was named 'Marinobacter litoralis SW-45'. This study further demonstrates successful utilization of the halophilic M. litoralis SW-45 lipase (MLL) for butyl ester synthesis from crude palm fruit oil (CPO) and kernel oil (CPKO) in heptane and solvent-free system, respectively, using hydroesterification. Hydrolysis and esterification of enzymatic [Thermomyces lanuginosus lipase (TLL)] hydrolysis of CPO and CPKO to free fatty acids (FFA) followed by MLL-catalytic esterification of the concentrated FFAs with butanol (acyl acceptor) to synthesize butyl esters were performed. A one-factor-at-a-time technique (OFAT) was used to study the influence of physicochemical factors on the esterification reaction. Under optimal esterification conditions of 40 and 45 °C, 150 and 230 rpm, 50% (v/v) biocatalyst concentration, 1:1 and 5:1 butanol:FFA, 9% and 15% (w/v) NaCl, 60 and 15 min reaction time for CPO- and CPKO-derived FFA esterification system, maximum ester conversion of 62.2% and 69.1%, respectively, was attained. Gas chromatography (GC) analysis confirmed the products formed as butyl esters. These results showed halophilic lipase has promising potential to be used for biosynthesis of butyl esters in oleochemical industry.
Insulin resistance is a key factor in metabolic disorders like hyperglycemia and hyperinsulinemia, which are promoted by obesity and may later lead to Type II diabetes mellitus. In recent years, researchers have identified links between insulin resistance and many noncommunicable illnesses other than diabetes. Hence, studying insulin resistance is of particular importance in unravelling the pathways employed by such diseases. In this review, mechanisms involving free fatty acids, adipocytokines such as TNF α and PPAR γ and serine kinases like JNK and IKK β , asserted to be responsible in the development of insulin resistance, will be discussed. Suggested mechanisms for actions in normal and disrupted states were also visualised in several manually constructed diagrams to capture an overall view of the insulin-signalling pathway and its related components. The underlying constituents of medicinal significance found in the Stevia rebaudiana Bertoni plant (among other plants that potentiate antihyperglycemic activities) were explored in further depth. Understanding these factors and their mechanisms may be essential for comprehending the progression of insulin resistance towards the development of diabetes mellitus.
The benefits of gut microbiota-derived short-chain fatty acids (SCFAs) towards health and metabolism have been emerging since the past decade. Extensive studies have been carried out to understand the mechanisms responsible in initiating the functionalities of these SCFAs towards body tissues, which greatly involves the SCFA-specific receptors free fatty acid receptor 2 (FFAR2) and free fatty acid receptor 3 (FFAR3). This review intends to discuss the potential of SCFAs particularly in regulating insulin secretion in pancreatic β-cells, by explaining the production of SCFAs in the gut, the fate of each SCFAs after their production, involvement of FFAR2 and FFAR3 signalling mechanisms and their impacts on insulin secretion. Increased secretion of insulin after SCFAs treatments were reported in many studies, but contradicting evidence also exist in several other studies. Hence, no clear consensus was achieved in determining the true potential of SCFA in regulating insulin secretion. In this review, we explore how such differences were possible and hopefully be able to shed some perspectives in understanding SCFAs-signalling behaviour and preferences.
This paper examines the processing steps of extracting palm oil from fresh fruit bunches in a way that may impact on the formation of chloropropandiol fatty esters (3-MCPD esters), particularly during refining. Diacylglycerols (DAGs) do not appear to be a critical factor when crude palm oils are extracted from various qualities of fruit bunches. Highly hydrolysed oils, in spite of the high free fatty acid (FFA) contents, did not show exceptionally high DAGs, and the oils did not display a higher formation of 3-MCPD esters upon heat treatment. However, acidity measured in terms of pH appears to have a strong impact on 3-MCPD ester formation in the crude oil when heated at high temperatures. The differences in the extraction process of crude palm oil from current commercial processes and that from a modified experimental process showed clearly the effect of acidity of the oil on the formation of 3-MCPD esters. This paper concludes that the washing or dilution step in palm oil mills removes the acidity of the vegetative materials and that a well-optimised dilution/washing step in the extraction process will play an important role in reducing formation of 3-MCPD esters in crude palm oil upon further heat processing.
In the present work, the influence of microwave power and heating times on the quality
degradation of corn oil was evaluated. Microwave heating test was carried out using a domestic
microwave oven for different periods at low- and medium-power settings for the corn oil sample.
The changes in physicochemical characteristics related to oil degradation of the samples during
heating were determined by standard methods. In this study, refractive index, free fatty acid
content, peroxide value, p-anisidine value, TOTOX value, viscosity and total polar compound
of the oils all increased with increasing heating power and time of exposure. In GLC analysis,
the percentage of linoleic acid tended to decrease, whereas the percentage of palmitic, stearic
and oleic acids increased. The C18:2/C16:0 ratio decreased in all oil samples with increasing
heating times. Exposing the corn oil to various microwave power settings and heating periods
caused the formation of hydroperoxides and secondary oxidation products. The heating reduced
the various tocopherol isomers in corn oil and highest reduction was detected in γ-tocopherol.
Longer microwave heating times resulted in a greater degree of oil deterioration. Microwave
heating caused the formation of comparatively lower amounts of some degradative products in
the oil samples heated at low-power setting compared to medium-power setting. The present
analysis indicated that oil quality was affected by both microwave power and heating time.
Salinity is one of the major constraintsin the rice production worldwide. Rice plants have moderate tolerance towardssalinity. Salinitychangescell membrane permeability and fatty acid compositionsby releasing the free fatty acids. Nonetheless, the effect of exogenous fatty acid such as arachidonic acid (AA) on rice grown on saline soil is yetunknown. Theobjective of the current study isto determine the effectofAA onthe morphological traits and freefatty acidsofrice plantgrown under saline conditions.Rice plants grown on saline soil (EC=12 ds/m)were treated with 50 μMAAon day 45 after transplant. Leaves and panicleswere sampledafter two weeks of treatment and analysed for fatty acid profile using GC-MS. Themorphological traits were observedat the maturity stage. Results showed that AA treatment improved the grain fill-in of the saline stress riceand reduced the accumulation of free fatty acids in the cell. The AAtreatment also increased the linoleic acid (18:2), linolenic acid (18:3) in paniclesand, dihomo-γ-linolenic acid(20:3) and nervonic acid (24:1) in leaves. The finding suggests that exogenous AAregulates salinity stress in rice by reducing the accumulation offree fatty acids.